Power boat, sailboat and yacht builders and dealers

 Bulletin: RollerTrol™ Automation Systems is Launched!  
  • We have been busy making and selling 12v marine roller blinds for some time, and we have decided to start selling the components at RollerTrol.com so others can do the same.
  • Take a look at our online store for tubular motors and other associated products - make your own custom blinds that fit your boat perfectly!
  • While you're at it, check out our tubular motors with built-in radio controllers. When used with our multi-channel remotes, you can control all your blinds with a single remote!
  End Bulletin: RollerTrol™ Automation Systems  
light duty, low power consumption DC/AC 12v portable mini fridge for your boat
Installing a practical, low cost DC/AC 12v mini fridge on your boat
that uses a solid state electronic technology with no compressor
by Adrian Biffen

(for complementary boating products such as 12v lighting control and 12v motorized blinds and shades, see our RV & boat automation DIY kit store)
I like a little cream with my morning coffee so I had to figure out a way to keep things cool on Serenade, our 30' sailboat. She has a nice big insulated icebox, but I find that maintaining ice supplies to be somewhat of a hassle. We were spending about five bucks for 2 blocks of ice every time it needed to be replenished, and I figured this would justify the cost of buying some kind of refrigeration unit.

If you're going offshore or sailing through areas with limited sources of supply, you probably need to consider a robust compressor based cold plate system in order to support a large volume of refrigeration and freezing capacity. In our case, most of the time we are only a day or two away from civilization, so I just needed something compact and efficient to keep dairy products and meats cooled for a few days, and I don't need to freeze anything for long term storage.portable DC mini fridge

I discovered a type of solid state electronic technology based on something called the Peltier Effect that fitted the bill perfectly.  In 1834, a scientist named Jean Peltier discovered that passing an electric current through two dissimilar metals would cause a temperature change and thus cooling to take place (it was really the opposite principle of the thermocouple that creates voltage when heated). This results in a small heat pump, later referred to as a thermo-electric cooler (TEC). A TEC can also provide heat to keep food warm if the current is reversed (switchable on many units).

This technology has now been refined to the point where it can be applied practically to compact refrigeration systems. Except for a small fan, they have no moving parts, no compressor noise, no environmentally damaging refrigerant gas and they provide reasonably efficient cooling at a very reasonable price (under a $100 for a small one). They run on 12v DC, but many models will also run on standard AC dock power as well. They are also very compact, an important factor if you have limited on-board space.

Coleman 40 Qt. RoadTrip Vertical/Horizontal Thermoelectric Cooler: CM I installed a unit on our boat (5 liters of internal space) which consumes around 30 watts and my solar power system has no problem running it continuously. I am considring upsizing to the 15 liter model (pictured above with open door) that has 3 times the internal volume and consumes only 50 watts (max). It is only 440 mm (17 inches) high and will fit into a very compact space.

We have initiated a number of improvement projects for Serenade since she was purchased, and we have created a series of articles detailing the work that has been done. Here are the relevant pages in this series:

(1) Wireless remote control autopilot
(2) Diesel removal & 4 stroke outboard engine mount
(3) Cockpit Bimini
(4) Tender davits on stern
(5) Waste management holding tank system
(6) Solar panel, PWM charge controller and deep cycle battery system
(7) Propane Fireplace